摘要：本文主要研究的内容是建立和优化硫酸锌产品中残留氧化物的测定方法，并设法去除或降低残留氧化物。主要采用氧化还原电位（ORP）法，以不同的电解质溶液作为测试使用的溶剂，将各饲料用硫酸锌样品溶于电解质溶液中，使用ORP电极对其进行定性、定量的测定。分别以氯化钾溶液及磷酸盐缓冲溶液作为电解质溶液进行比较，结果表明氯化钾溶液更适合作为本次研究使用的电解质溶液。以具有不同氧化还原性的物质：过氧化氢、高锰酸钾、柠檬酸作为残留氧化物含量的定量基准对其进行ORP值测定，数据表明，可以以柠檬酸作为定量基准。此外，在110℃对硫酸锌样品进行烘干后，对其ORP值测定后发现其数值有所下降，因此表明残留氧化物的含量确实有所下降，该法有效。21052
毕业论文关键词：氧化还原电位；电解质溶液；高锰酸钾；柠檬酸
Determine and Eliminate the Residual Oxide in Feed Additive Zinc Sulfate
Abstract: The main contents of this study is to establish and optimize the determination of residual oxide in Zinc Sulfate products, and try to remove or reduce the content of the residual oxide. The main method of this research is the oxidation-reduction potential (ORP) measurement. In the experiment, various electrolyte solutions are used as the solvent. Firstly, the samples of the feed additive Zinc Sulfate are dissolved in the electrolyte solution, and use the ORP electrodes to determine the samples’ properties and contents. Secondly, compare the differences between the two electrolyte solutions: the Potassium Chloride Solution and the Phosphate Buffer Solution. The results show that the Potassium Chloride Solution as an electrolytic solution is more suitable in this study. Thirdly, measure the ORP value of the Hydrogen Peroxide, Potassium Permanganate, and Citric Acid, which of the three substances have different redox properties. These three substances are used as a quantitative benchmark of the residual oxide content. The test data show that, the Citric Acid can be used as a quantitative benchmark of the residual oxide in Zinc Sulfate products. Further, after drying the Zinc Sulfate samples in 110℃ and determine its ORP, the results show that the ORP value decreased. Thus, the fact indicating that the content of the residual oxide is really decreased, so the method is valid.
Keywords: oxidation-reduction potential ; electrolyte solution ; Potassium Permanganate ; Citric Acid
 
目录
1 前言    1
1.1 开题依据    1
1.1.1 锌对动物的作用    1
1.1.2 残留氧化物危害概述    1
1.1.3 ORP的概念及原理    2
1.2 文献综述    3
1.2.1 锌对动物的营养价值    3
1.2.2 残留氧化物检测技术的研究现状    4
1.2.3 残留氧化物的去除    5
1.2.4 存在的问题    5
2 仪器和试剂    6
2.1 实验仪器    6
2.2 实验试剂    6
3 实验部分    8
3.1 定性测量饲料用硫酸锌中氧化物的残留    8
3.1.1 氯化钾溶液的配制    8
3.1.2 ZnSO4-KCl测试液的配制    8
3.1.3 ZnSO4-KCl测试液ORP值、pH值的测定    8
3.1.4 氯化钾溶液ORP值的测定    8
3.1.5 磷酸盐缓冲溶液（PBS）的配制    8
3.1.6 ZnSO4-PBS-KCl测试液的配制    9
3.1.7 ZnSO4-PBS-KCl测试液ORP值的测定    9
3.2 定量测量饲料用硫酸锌中氧化物的残留    9
3.2.1 以H2O2为定量基准测量氧化物的残留    9
3.2.2 以KMnO4为定量基准测量氧化物的残留    9 饲料用硫酸锌中残留氧化物的测定及消除:http://www.751com.cn/huaxue/lunwen_13080.html